WDB ACFT HAS ALTDEV DUE WX; TSTM ACTIVITY.

Narrative

ENRTE LAX-FRA AT FL330; CLRED BY ATC FROM OVER LAS TO DIRECT GREEN BAY VORTAC. APPROX 15 NM E OF DENVER; NOTED A LINE OF TSTMS XING OUR INTENDED PATH; DISTANCE APPROX 100 NM. APPROX 50 NM SW OF LINE; I BEGAN A 90 DEG R TURN TO HDG 135 DEGS WITH ATC APPROVAL. FLEW THIS HDG APPROX 75 NM TO BREAK IN LINE WHERE OTHER ACFT WERE SUCCESSFULLY PENETRATING. BEGAN 90 DEG L TURN TO PENETRATE THROUGH BREAK IN LINE OF TSTMS. PAX HAD; SEVERAL MINS BEFORE; BEEN INSTRUCTED BY COCKPIT/CABIN PA ANNOUNCEMENT TO FASTEN SEAT BELTS; AS WERE FLT ATTENDANTS OVER COCKPIT/CABIN INTERCOM TO PUT EVERYTHING AWAY AND FASTEN SEAT BELTS; ETC. 3/4 WAY THROUGH THIS 90 DEG TURN; MODERATE TURB COMMENCED AND MACH DROPPED OFF FROM .84 TO .81. AUTOPLT LET ACFT DSND 250 FT TO MAINTAIN MACH; THEN DISCONNECTED ITSELF. CAPT HAD BEEN CONDUCTING THE TURN USING 'CTL WHEEL STEERING' MODE OF AUTOPLT IN WHICH THE AUTOPLT MAINTAINS THE ACFT'S ALT WHILE THE PLT MANUALLY CTLS BANK ANGLE. CAPT TOOK PITCH CTL OF ACFT ALSO WHEN ALT HOLD FUNCTION DISCONNECTED ITSELF; AND SLOWLY APPLIED BACK PRESSURE TO ARREST DSCNT; NOT WISHING TO LOSE ANYMORE SPD IN WHAT BECAME THEN LIGHT TO MODERATE TURB. AS A RESULT; THEN ACFT DSNDED TO 450 FT LOW (32550 FT) BEFORE LEVEL OFF AND CLB BACK TO FL330 WAS AFFECTED. IT IS ASSUMED THAT THE ALTDEV WAS NOTED BY ATC ALTHOUGH CTR MADE NO COMMENT. SEVERAL PAX WERE SHAKEN UP OR SLIGHTLY INJURED DUE TO THEIR HAVING FAILED TO FASTEN THEIR SEAT BELTS. 2 FLT ATTENDANTS WERE ALSO INJURED. ONE CUT ON THE ANKLE BY 1 OF 2 SERVING CARTS THAT HAD NOT BEEN PROPERLY STOWED IN THE AFT GALLEY AREA. THIS TYPE OF ALTDEV IS NOT RARE TO ACFT EQUIPPED WITH 'SOFT' AUTOPLTS THAT ARE PROGRAMMED TO SACRIFICE ALT TO MAINTAIN MACH SPD. FLCS MUST BE EXTREMELY VIGILANT AND IN THIS CASE; READY TO DISCONNECT THEM BEFORE ALTDEVS BECOME EXCESSIVE. CABIN CREWS MUST BE MUCH MORE VIGILANT OF NON COOPERATION BY PAX WHEN THE SEAT BELT SIGN IS ILLUMINATED; NOT WISHING TO AWAKEN OR DISTURB THE PAX IS NO EXCUSE. AS FOR SERVING CARTS -- I HAVE ALWAYS FELT THAT THERE SHOULD BE WAYS TO DESIGN THEM TO MAKE THEM LESS CUMBERSOME AND LESS DANGEROUS ABOARD PAX ACFT UNDER ANY KIND OF FLT CONDITIONS; NOT JUST BAD WX. UNTIL THEY CAN BE; I'D LIKE TO SEE THEM BANNED FROM COMMERCIAL ACFT.