HISTORY OF FLIGHTOn August 15, 2015, at 2000 eastern daylight time, a Head AX9-118 hot air balloon, N40104 incurred minor damage when it collided with powerlines after landing in a field, near New Holland, Pennsylvania. The commercial pilot sustained minor injuries, and the two passengers were seriously injured. The local sightseeing flight was conducted under the provisions of Title 14 Code of Federal Regulations Part 91. Visual meteorological conditions prevailed, and no flight plan was filed for the flight that originated at the operator's base in Intercourse, Pennsylvania about 1855.
Approximately 45 minutes into the sightseeing, the pilot asked the two passengers if they would mind landing about ten minutes early, as the sun was beginning to set. He proceeded to scan the area for a suitable landing spot and selected a hay field as the most appropriate place. He stated he did not see any other landing spots and he had approximately 50% fuel remaining. The pilot then informed the ground crew via radio of the location, and they acknowledged and proceeded to the location. During final approach, he stated "everything looked good for landing." The basket grazed the last few rows of corn before touching down in an open field where it bounced and continued north-northeast for approximately 50 feet.
As the basket was secured by the ground crew, the pilot started the shutdown procedures and was told that the envelope was deflating. The pilot noticed the vent line had detached from the basket and was pinched between the ground and the basket as it drug along the ground. He tugged on it and pulled it free. As the envelope lost air, it began to elongate and blow downwind where it draped over the powerlines paralleling the field. The result was an electrical arc that went from the powerlines through the balloon cables to the basket, and electrocuted the pilot and passengers.
According to the passenger, he and his fiancé arrived at the balloon launch location at approximately 1800 and waited for about 45 minutes before they took off. The takeoff and flight were uneventful. They stayed relatively low, never getting above 1,000 feet and the pilot took them down lower a few times so he could check the ground wind speed, but nothing seemed out of the ordinary. The pilot asked the passengers if they could land 10 minutes early; assuming because it was starting the get dark. He also heard the pilot radio the ground crew and directed them to a specific location; to which the ground crew acknowledged.
As they were descending, the passenger stated he saw the field where they were going to land and it looked a little narrow and had powerlines on the far side, but the pilot did not seem concerned. As they landed they bounced and the basket tipped slightly forward, but neither he nor his fiancé remember anything after landing.
Eyewitnesses parked on the adjacent road south of the field, reported that the accident balloon approached the intended landing area from the south-southwest. As the balloon approached the landing site, it grazed the last few rows of corn before bouncing along the ground several times before the people on the ground chased the basket and grabbed onto it; As the basket was secured, with the passengers still inside, the balloon draped over the powerlines and started to smoke.
PERSONNEL INFORMATION
The pilot, age 52, held a commercial pilot certificate, with a rating for lighter-than-air free balloon. He did not hold, nor was he required to maintain, a Federal Aviation Administration (FAA) medical certificate. The pilot reported 519 hours of total flight experience in lighter than air aircraft and 31of those hours were in the same make and model as the accident balloon.
AIRCRAFT INFORMATION
According to FAA records and the balloon manufacturer, the balloon was manufactured in 1999, and was equipped with four propane tanks, a wicker basket, and an 119,544 cubic-foot envelope. The inflated envelope with basket was approximately 79 feet tall, and the inflated diameter was 62 feet. The most recent annual inspection was performed on June 24, 2015, and at that time the balloon had accumulated 81.5 hours of total time in service.
METEOROLOGICAL INFORMATION
At the time of departure and during the approximate 50-minute flight, weather observations from Lancaster Airport (LNS), Lancaster, Pennsylvania, located approximately 9 miles to the west of the accident site, recorded wind from 190 degrees at 6 knots, 10 miles visibility and clear skies, temperature 29 ° C with a dew point 17 °C. The barometric altimeter setting was 30.09 inches of mercury.
During a telephone interview, when asked about the wind conditions, the pilot stated that the wind was 6 to 8 knots at the takeoff location. However, when they got to the launch site, the wind speed appeared to be "a little higher" than that, so they waited about 45 minutes for the winds to decrease before departing.
WRECKAGE AND IMPACT INFORMATION
According to an FAA inspector who travelled to the accident site, the envelope, lines, basket and all major components were accounted for at the scene. The envelope was oriented on a northeast heading where it impacted the electrical power lines that were about 30 feet above ground level (agl) on the north side of the field. The field was a symmetrical rectangle, approximately 500 feet long on the west-east side and 150 feet wide on the border of a road running roughly north/south. The eastern portion of the field was bordered by farm buildings and a residential structure. The south portion of the field was bordered by mature corn.
The envelope remained undamaged and the stitching was intact. Several cables coming from the envelope to the basket and the skirt exhibited damage consistent with electrical arcing. The basket, instrumentation and components were not damaged.
Examination of the power lines revealed that they were not damaged during the accident.
ADDITIONAL INFORMATION
Witness Photographs and Video
Several photos and a video were submitted by witnesses who were parked in a car on an adjacent road, approximately 600 feet south of the accident location. The witness photographed the balloon coming from the south southwest at about 200 feet agl through touchdown and subsequent powerline contact. Review of the sequential photographs and video showed the balloon descending onto the last few rows of corn, bouncing on the ground, before ground personnel secured the basket. Once the basket was secured, the envelope continued to collapse and drift into the powerlines. As the balloon draped over the powerlines, smoke began emanating from the area around the basket.
FAA-H-8083-11A Balloon Flying Handbook
Chapter 8, "Landing and Recovery," stated, "Having the skill to predict the balloon's track during the landing approach, touching down on the intended landing target and stopping the balloon basket in the preferred place can be very satisfying. It requires a sharp eye trained to spot the indicators of wind direction on the ground. Dropping bits of tissue, observing other balloons, smoke, steam, dust, and tree movement are all ways to predict the balloon track on its way to the landing site. During the approach, one of the pilot's most important observations is watching for power lines."
The chapter further stated "When selecting a landing site, three considerations in order of importance are: safety of passengers, as well as persons and property on the ground; landowner relations; and ease of recovery."
Some questions the pilot should ask when evaluating a landing site were: "• Is it a safe place for my passengers and the balloon? • Would my landing create a hazard for any person or property on the ground? • Will my presence create any problems (noise, startling animals, etc.) for the landowner?"